Lifecycle spatial effects of super-large diameter shield working shafts in silty clay strata in the middle and lower reaches of the Yellow River
Zhai Bin1, Liu Yan2,3*, Liu Junting4, Yuan Peng5, Sun Feng5, Wang Wei1, Zhang Liangliang5, Chen Fangyan2
1. Jinan City Construction Group, Jinan 250031, Shandong, China; 2. School of Civil Engineering and Architecture, University of Jinan, Jinan 250022, Shandong, China; 3. Engineering Technology Research Center on Urban Underground Engineering Support and Risk Monitoring of Shandong Province, Jinan 250022, Shandong, China; 4. The First Company of China Eighth Engineering Bureau Co., Ltd., Jinan 250100, Shandong, China; 5. China Railway SiYuan Surevy and Design Group Co., Ltd., Wuhan 430063, Hubei, China
Abstract: To investigate the complex three-dimensional spatial effects of super large diameter shield working shafts in typical silty clay strata of the Yellow River basin, a deep foundation pit of a shield working shaft in Jinan along the Yellow River basin was taken as the engineering background. Numerical simulation and field monitoring were adopted to systematically study the influences of different length-to-width ratios and vertical installation positions of ring frame beams on the spatial effects of the foundation pit. The deformation characteristics of retaining walls and ground settlement patterns of the shield working shaft were revealed. The results show that the maximum horizontal displacement of retaining walls and ground settlement vary most significantly when the length-to-width ratio L/B of the working shaft is less than or equal to 2. When L/B>2, the deformations tend to be stable, and the maximum horizontal displacement hardly increases with the enlargement of the long-side dimension. Compared with the construction period, the position of the ring frame beam exerts a greater influence on the foundation pit during the service period. Installing the bottommost ring frame beam near the maximum deformation zone of the retaining wall can effectively improve the overall deformation control performance. The research findings can provide a theoretical basis and practical references for the design and construction of shield working shafts under similar geological conditions.
翟彬,刘燕,刘峻廷,袁鹏,孙峰,王伟,张亮亮,陈方岩. 黄河中下游粉质黏土地层超大直径盾构工作井空间效应研究[J]. 隧道与地下工程灾害防治, 2026, 8(3): 89-101.
Zhai Bin, Liu Yan, Liu Junting, Yuan Peng, Sun Feng, Wang Wei, Zhang Liangliang, Chen Fangyan. Lifecycle spatial effects of super-large diameter shield working shafts in silty clay strata in the middle and lower reaches of the Yellow River. Hazard Control in Tunnelling and Underground Engineering, 2026, 8(3): 89-101.
[1] 《中国公路学报》编辑部. 中国隧道工程学术研究综述·2015[J].中国公路学报, 2015, 28(5): 1-65. Editorial Department of China Journal of Highway and Transport. Review on China's tunnel engineering research: 2015[J]. China Journal of Highway and Transport, 2015, 28(5): 1-65. [2] 徐中华. 上海地区支护结构与主体地下结构相结合的深基坑变形性状研究[D]. 上海:上海交通大学, 2007: 1-22. Xu Zhonghua. Deformation behavior of deep excavations supported by permanent structure in Shanghai soft deposit[D]. Shanghai: Shanghai Jiao Tong University, 2007: 1-22. [3] 徐杰, 张振光, 李海祥. 考虑空间土拱效应的非饱和地层圆形基坑围护结构侧向土压力计算方法[J]. 岩土力学, 2026, 47(1): 245-254. Xu Jie, Zhang Zhenguang, Li Haixiang. Calculation methods of lateral earth pressure on retaining structures for a circular foundation pit in unsaturated soils considering the spatial soil arching effect[J]. Rock and Soil Mechanics, 2026, 47(1): 245-254. [4] 饶秋琛, 李琦, 王倩. 空间效应下长条形基坑分段地下连续墙支护特性研究[J]. 岩土工程学报, 2022, 44(增刊1): 104-108. Rao Qiuchen, Li Qi, Wang Qian. Supporting characteristics of segmental diaphragm walls in strip foundation pits under spatial effects[J]. Chinese Journal of Geotechnical Engineering, 2022, 44(S1): 104-108. [5] 李泽文, 谭勇, 廖少明, 等. 上海超深基坑地下连续墙的空间变形特性实测分析[J]. 岩土工程学报, 2024, 46(11): 2380-2390. Li Zewen, Tan Yong, Liao Shaoming, et al. Field tests on performance of diaphragm wall for an ultra-deep excavation in Shanghai soft ground[J]. Chinese Journal of Geotechnical Engineering, 2024, 46(11): 2380-2390. [6] 赵泳皓, 甄洁, 栗晴瀚, 等. 软土地区超深基坑对既有地铁变形影响分析[J]. 岩土工程学报, 2025, 47(增刊2): 205-211. Zhao Yonghao, Zhen Jie, Li Qinghan, et al. Analysis of influence of ultra-deep foundation pit on deformation of existing subway in soft soil area[J]. Chinese Journal of Geotechnical Engineering, 2025, 47(S2): 205-211. [7] 黄生根, 张义, 霍昊, 等. 软土地区深基坑支护工程格构柱变形规律研究[J]. 岩土力学, 2023, 44(增刊1): 533-538. Huang Shenggen, Zhang Yi, Huo Hao, et al. Study on deformation law of lattice columns in deep foundation pits in soft soil area[J]. Rock and Soil Mechanics, 2023, 44(S1): 533-538. [8] 杨雪强, 刘祖德, 何世秀. 论深基坑支护的空间效应[J]. 岩土工程学报, 1998, 20(2): 74-78. Yang Xueqiang, Liu Zude, HeShixiu. Research about spatial effect of deep pit supporting[J]. Chinese Journal of Geotechnical Engineering, 1998, 20(2): 74-78. [9] 郑刚, 曾超峰. 基坑开挖前潜水降水引起的地下连续墙侧移研究[J]. 岩土工程学报, 2013, 35(12): 2153-2163. Zheng Gang, Zeng Chaofeng. Lateral displacement of diaphragm wall by dewatering of phreatic water before excavation[J]. Chinese Journal of Geotechnical Engineering, 2013, 35(12): 2153-2163. [10] 张志强. 黄土地区桩锚支护深基坑受力分析与变形控制[J]. 施工技术(中英文), 2025, 54(4): 88-94. Zhang Zhiqiang. Stress analysis and deformation control of pile-anchored support in deep foundation excavations in loess area[J]. Construction Technology, 2025, 54(4): 88-94. [11] 雷明锋, 彭立敏, 施成华, 等. 长大深基坑施工空间效应研究[J]. 岩土力学, 2010, 31(5): 1579-1584. Lei Mingfeng, Peng Limin, Shi Chenghua, et al. Research on construction spatial effects in large-long-deep foundation pit[J]. Rock and Soil Mechanics, 2010, 31(5): 1579-1584. [12] 聂庆科, 胡建敏, 吴刚. 深基坑双排桩支护结构上的变形和土压力研究[J]. 岩土力学, 2008, 29(11): 3089-3094. Nie Qingke, Hu Jianmin, Wu Gang. Deformation and earth pressure of a double-row piles retaining structure for deep excavation[J]. Rock and Soil Mechanics, 2008, 29(11): 3089-3094. [13] 吴刚, 白冰, 聂庆科. 深基坑双排桩支护结构设计计算方法研究[J]. 岩土力学, 2008, 29(10): 2753-2758. Wu Gang, Bai Bing, Nie Qingke. Research on calculation method of double-row piles retaining structure for deep excavation[J]. Rock and Soil Mechanics, 2008, 29(10): 2753-2758. [14] 王文正, 张艳秋, 李栋, 等. 考虑空间效应的深基坑变形特性研究[J]. 山西建筑, 2024, 50(10): 1-5. Wang Wenzheng, Zhang Yanqiu, Li Dong, et al. Research on deformation characteristics of deep foundation pit considering spatial effects[J]. Shanxi Architecture, 2024, 50(10): 1-5. [15] 刘念武, 陈奕天, 龚晓南, 等. 软土深开挖致地铁车站基坑及邻近建筑变形特性研究[J]. 岩土力学, 2019, 40(4): 1515-1525. Liu Nianwu, Chen Yitian, Gong Xiaonan, et al. Analysis of deformation characteristics of foundation pit of metro station and adjacent buildings induced by deep excavation in soft soil[J]. Rock and Soil Mechanics, 2019, 40(4): 1515-1525. [16] 郝大为, 江政律, 黄威然, 等. 狭长深基坑空间效应特征研究: 以深圳白石洲地铁站为例[J]. 铁道勘察, 2025, 51(5): 51-57. Hao Dawei, Jiang Zhenglü, Huang Weiran, et al. Study on the characteristics of spatial effects in long and narrow deep excavations: a case study of Shenzhenbaishizhou metro station[J]. Railway Investigation and Surveying, 2025, 51(5): 51-57. [17] 顾正瑞, 徐中华, 杨涛. 基于小应变本构模型的深基坑受力与变形性状三维有限元分析[J]. 施工技术, 2021, 50(1): 42-48. Gu Zhengrui, Xu Zhonghua, Yang Tao. Three dimensional finite element analysis of the behavior of deep foundation excavation using small strain constitutive model[J]. Construction Technology, 2021, 50(1): 42-48. [18] 孙政波, 张文涛, 赵俊键, 等. 软土地区超深基坑分坑及地中壁空间效应研究[J]. 广西大学学报(自然科学版), 2025, 50(4): 770-785. Sun Zhengbo, Zhang Wentao, Zhao Junjian, et al. Sub-pit and cross wall spatial effect analysis for ultra-deep foundation pit in soft soil[J]. Journal of Guangxi University(Natural Science Edition), 2025, 50(4): 770-785. [19] The Editorial Team. Smart underground engineering: Innovation and sustainable development[J]. Smart Underground Engineering, 2025, 1(1): 2. [20] 王成华, 王晓旋. 深筒形基坑空间效应的定量化研究[J]. 水利水电技术, 2020, 51(5): 1-8. Wang Chenghua, Wang Xiaoxuan. A quantitative study on spatial effect of deep-cylindrical foundation pit[J]. Water Resources and Hydropower Engineering, 2020, 51(5): 1-8. [21] JGJ 120—2012 建筑基坑支护技术规程[S].
2026, Vol. 8 
