Experimental study on seismic response of shield tunnel
GENG Ping1, HE Chuan1, ZHANG Jing2, HE Yue1, GUO Xiangyu1, CHEN Pingliang1, WANG Qi1, YANG Qi1, CHEN Changjian1
1. MOE Key Laboratory of Transportation Tunnel Engineering, Southwest Jiaotong University, Chengdu 610031, Sichuan, China; 2. China Railway First Survey and Design Institute Group Co., Ltd., Xian 710043, Shaanxi, China
Abstract: When encountering strong earthquake, geological conditions or structural stiffness mutation, serious earthquake damage may occur to shield tunnel, and the earthquake damage mainly concentrates on the joints. Through shaking table test and indoor static test, a series of studies were carried out for the weak seismic parts or conditions such as the shield tunnel passing through the soft and hard interface stratum, the joint of cross passage and the longitudinal. The results showed that the seismic response of the shield tunnel in the hard-soft interface stratum still had followability, but showed a “double peak” phenomenon, and the larger internal force response values were distributed in the range of 2.5 times the tunnel diameter on both sides of the stratigraphic interface. The connection stiffness of shield tunnel and transverse passage had an effect on mechanical response of tunnel, and the influence range of rigid connection on the main tunnel was about 3 times of the width of a cross passage, and it was reduced to 1.5 ~ 2 times in the case of flexible connection. The longitudinal joints of shield tunnel mainly bear axial tension or pressure under the seismic. The segments on the bolt hole side and sleeve side were dominated by compressive strain and tensile strain, respectively. The failure test showed that the sleeve and the segment constitute a destructive chain. The sleeve and the segment exhibit slip failure and tension crack failure, respectively. The research can provide a reference for seismic design of shield tunnel.
耿萍,何川,张景,何悦,郭翔宇,陈枰良,王琦,杨琪,陈昌健. 盾构隧道地震响应试验研究[J]. 隧道与地下工程灾害防治, 2020, 2(2): 47-57.
GENG Ping, HE Chuan, ZHANG Jing, HE Yue, GUO Xiangyu, CHEN Pingliang, WANG Qi, YANG Qi, CHEN Changjian. Experimental study on seismic response of shield tunnel. Hazard Control in Tunnelling and Underground Engineering, 2020, 2(2): 47-57.
[1] 李乔,赵世春. 汶川大地震工程震害分析[M].成都:西南交通大学出版社, 2008. [2] 何川,耿萍,晏启祥. 汶川大地震隧道工程震害初步分析[M] //宋胜武.汶川大地震工程震害调查分析与研究.北京:科学出版社,2009. [3] 小泉淳. 盾构隧道的抗震研究及算例[M].张稳军,袁大军,译.北京: 中国建筑工业出版社, 2009. [4] KEIBUN Saito, KENJI Yamane, ATSUSHI Koizumi. A study on seismic behavior of shield tunnel including shaft in longitudinal direction[J]. Journal of Tunnel Engineering, JSCE, 2006, 16: 121-132. [5] 王维. 软硬突变地层盾构隧道地震响应特性研究[D].成都:西南交通大学, 2015. WANG Wei. The study of seismic response of shield tunnel crossing interface of soft and hard strata[D].Chengdu: Southwest Jiaotong University, 2015. [6] 张景,何川,耿萍,等. 穿越软硬突变地层盾构隧道纵向地震响应振动台试验研究[J].岩石力学与工程学报,2017, 36(1): 68-77. ZHANG Jing, HE Chuan, GENG Ping, et al. Shaking table tests on longitudinal seismic response of shield tunnel through soft-hard stratum junction[J]. Chinese Journal of Rock Mechanics and Engineering, 2017, 36(1): 68-77. [7] 段志慧. 软土地基地铁盾构隧道地震动力响应研究[D]. 天津:河北工业大学, 2016. DUAN Zhihui. Study on seismic response of shield tunnel in soft soil foundation[D].Tianjin: Hebei University of Technology, 2016. [8] 段志慧,窦远明,王建宁,等. 软土地基盾构隧道地震动力响应振动台模型试验研究[J].科学技术与工程,2017, 17(2): 106-110. DUAN Zhihui, DOU Yuanming, WANG Jianning, et al. Shaking table test for seismic response of shield tunnel in soft soil foundation[J]. Science Technology and Engineering, 2017, 17(2): 106-110. [9] 袁勇,包蓁,禹海涛,等. 考虑行波效应的盾构隧道多点振动台试验[J].中国公路学报,2017, 30(8): 174-182. YUAN Yong, BAO Zhen, YU Haitao, et al. Multi-point vibration table test of shield tunnel with traveling wave effect considered[J]. China Journal of Highway and Transport, 2017, 30(8): 174-182. [10] 袁勇,禹海涛,李翀,等. 长隧道的地震响应与控制方法研究[C] //中国土木工程学会2017年学术年会.上海: 中国土木工程学会,2017. YUAN Yong, YU Haitao, LI Chong, et al. Research on seismic response and control method of long tunnel[C] //Academic Annual Meeting of China Society of Civil Engineering. Shanghai: CCES, 2017. [11] BAO Z, YUAN Y, YU H T. Multi-scale physical model of shield tunnels applied in shaking table test[J].Soil Dynamics and Earthquake Engineering, 2017, 100: 465-479. [12] 周军,伍伟林,胡瑞青. 可液化砂土地层盾构隧道地震响应研究[J]. 铁道工程学报,2017, 34(12): 83-88. ZHOU Jun, WU Weilin, HU Ruiqing. Research on the seismic responses for shield tunnel in liquefiable soil[J]. Journal of Railway Engineering Society, 2017, 34(12): 83-88. [13] 彭加强,钟小春,王奇,等. 盾构隧道穿越液化地基上浮振动台试验分析[J]. 隧道建设(中英文),2018, 38(增刊2): 60-67. PENG Jiaqiang, ZHONG Xiaochun, WANG Qi, et al. Analysis on shaking table experiment for shield tunnel through liquefied foundation[J].Tunnel Construction, 2018, 38(Suppl.2): 60-67. [14] 王亚西. 隧道-土体-地表结构相互作用体系地震响应振动台试验研究[D].武汉:武汉理工大学, 2017. WANG Yaxi. Shaking table test research on seismic response of tunnel-soil-above ground structure interaction system[D]. Wuhan:Wuhan University of Technology, 2017. [15] 禹海涛,张敬华,袁勇,等. 盾构隧道-工作井节点振动台试验设计与分析[J].中国公路学报,2017,30(8): 183-192. YU Haitao, ZHANG Jinghua, YUAN Yong, et al. Design and analysis of shaking table test on shield tunnel-shaft junction[J]. China Journal of Highway and Transport, 2017, 30(8): 183-192. [16] 何悦,何川,耿萍,等. 盾构隧道联络横通道地震响应振动台试验[J].中国公路学报,2017, 30(8): 193-200. HE Yue, HE Chuan, GENG Ping, et al. Shaking table test on seismic response of structure at shield tunnel and transverse passage[J]. China Journal of Highway and Transport, 2017, 30(8): 193-200. [17] 耿萍,杨琪,何悦,等. 盾构隧道联络横通道的振动台试验与数值模拟[J].西南交通大学学报,2019: 1-9. GENG Ping, YANG Qi, HE Yue, et al. Shaking table test and numerical simulation of shield tunnel connecting cross passage[J]. Journal of Southwest Jiaotong University, 2019. DOI: 10.3969/j.issn.0258-2724.20180982. 1-9. [18] CHEN Z, LIANG S, SHEN H, et al. Dynamic centrifuge tests on effects of isolation layer and cross-section dimensions on shield tunnels[J].Soil Dynamics and Earthquake Engineering, 2018, 109: 173-187. [19] ZHANG J H, YUAN Y, YU H T. Shaking table tests on discrepant responses of shaft-tunnel junction in soft soil under transverse excitations[J]. Soil Dynamics and Earthquake Engineering, 2019, 120: 345-359. [20] ZHANG J H, YUAN Y, BAO Z, et al. Shaking table tests on the intersection of cross passage and twin tunnels[J]. Soil Dynamics and Earthquake Engineering, 2019, 124: 136-150. [21] ZHANG J H, YUAN Y, BAO Z, et al. Shaking table tests on shaft-tunnel junction under longitudinal excitations[J]. Soil Dynamics and Earthquake Engineering, 2020, 132: 106055.1-106055.14. [22] 董正方,张继康,蔡宝占,等. 地震作用下盾构隧道变形性能试验研究[J].世界地震工程,2019, 35(4): 125-132. DONG Zhengfang, ZHANG Jikang, CAI Baozhan, et al. Experimental study on deformation performance of shield tunnel under seismic action[J]. World Earthquake Engineering, 2019, 35(4): 125-132. [23] 耿萍,王琦,郭翔宇,等. 盾构隧道纵向接头抗拉性能试验研究[J].中国公路学报,2020,33(7): 124-134. GENG Ping, WANG Qi, GUO Xiangyu, et al. Pull-out test of longitudinal joints of shield tunnel[J]. China Journal of Highway and Transport, 2020, 33(7): 124-134. [24] 耿萍,郭翔宇,王琦,等. 盾构隧道纵向接头局部足尺试验研究[J].土木工程学报,2020, 53(1): 92-101. GENG Ping, GUO Xiangyu, WANG Qi, et al. Feasibility study on local full-scale experiment's boundary of longitudinal joint of shield tunnel[J]. China Civil Engineering Journal, 2020, 53(1): 92-101.
2020, Vol. 2 
