Field test research on applicability of grout materials in water-rich fractured rock grouting engineering
WANG Jiwei1, ZHANG Lianzhen2*, ZHANG Qingsong3, YANG Pei3, CHEN Xin3, WANG Jianhui1,HAN Zichuan2, WANG Hongchao2, SUN Zizheng4, TU Wenfeng4
1. The 5th Engineering Co., Ltd., China Railway 19th Bureau Group, Dalian 116600, Liaoning, China; 2. College of Pipeline and Civil Engineering, China University of Petroleum, Qingdao 266580, Shandong, China; 3. Geotechnical and Structural Engineering Research Center, Shandong University, Jinan 250061, Shandong, China; 4.School of Qilu Transportation, Shandong University, Jinan 250002, Shandong, China
Abstract: Relying on the actual engineering case of grouting water plugging in water-rich fractured rock of Qingdao Metro, the field test of the applicability of grouting materials was carried out. The applicability of regular cement slurry, cement-sodium silicate slurry, and superfine cement slurry under the water yield standard requirements of two inspection holes, 0.2 L·min-1·m-1 and 0.01 L·min-1·m-1, was studied. Suggestions for water plugging grouting materials in water-rich fractured rock that match the requirements of different standards were proposed. The applicability of the grouting material was verified by means of Borehole TV and actual excavation verification. Research indicated: it was difficult to meet the requirements of waterless operation by using regular cement slurry alone(the water yield from the borehole was less than 0.01 L·min-1·m-1), but after repeated grouting, the water yield from the borehole could meet the requirement of no more than 0.2 L·min-1·m-1. Cement-sodium silicate slurries had a short gel time, which could effectively limit the diffusion scope of the slurry. By coordination application of regular cement slurry and cement-sodium silicate slurry, the grouting effect was significantly better than regular cement single-liquid slurry; The superfine cement slurry had low particle size, which could effectively fill the micro-fracture space in the water-rich fractured rock and improve the water plugging efficiency of the tunnel surrounding rock. The use of regular cement slurry, cement-sodium silicate slurry and superfine cement slurry to carry out advanced curtain grouting of water-rich fractured rock could meet the requirements of tunnels waterless operation. The research results could provide a basis for the treatment design of grouting and field construction in water-rich fractured rock.
王纪伟, 张连震, 张庆松, 杨旆, 陈新, 王建辉, 韩子川, 王洪超, 孙子正, 屠文锋. 富水裂隙岩体注浆材料适用性现场试验研究[J]. 隧道与地下工程灾害防治, 2021, 3(1): 58-67.
WANG Jiwei, ZHANG Lianzhen, ZHANG Qingsong, YANG Pei, CHEN Xin, WANG Jianhui, HAN Zichuan, WANG Hongchao, SUN Zizheng, TU Wenfeng. Field test research on applicability of grout materials in water-rich fractured rock grouting engineering. Hazard Control in Tunnelling and Underground Engineering, 2021, 3(1): 58-67.
[1] 钱七虎. 地下工程建设安全面临的挑战与对策[J]. 岩石力学与工程学报, 2012,31(10): 1945-1956. QIAN Qihu. Challenges faced by underground projects construction safety and countermeasures[J]. Chinese Journal of Rock Mechanics and Engineering, 2012, 31(10): 1945-1956. [2] 李利平,朱宇泽,周宗青,等. 隧道突涌水灾害防突厚度计算方法及适用性评价[J]. 岩土力学,2020,41(增刊1): 41-50. LI Liping, ZHU Yuze, ZHOU Zongqing, et al. Calculation methods of rock thickness for preventing water inrush in tunnels and their applicability evaluation[J]. Rock and Soil Mechanics, 2020, 41(Suppl.1): 41-50. [3] HAN Chenghao, WEI Chenghao, ZHANG Chenghao, et al. Numerical investigation of grout diffusion accounting for the dynamic pressure boundary condition and spatiotemporal variation in slurry viscosity[J]. International Journal of Geomechanics, 2021, 21(4): 04021018. [4] 张连震,刘人太,张庆松,等. 软弱地层劈裂-压密注浆加固效果定量计算方法研究[J]. 岩石力学与工程学报,2018,37(5): 1169-1184. ZHANG Lianzhen, LIU Rentai, ZHANG Qingsong, et al. Calculation of reinforcement effect of fracturing-compaction grouting in soft strata[J]. Chinese Journal of Rock Mechanics and Engineering, 2018, 37(5):1169-1184. [5] LI Zhipeng, ZHANG Lianzhen, CHU Yuntian, et al. Research on influence of water-cement ratio on reinforcement effect for permeation grouting in sand layer[J]. Advances in Materials Science and Engineering, 2020(Suppl.1): 1-12. [6] 阮文军. 基于浆液粘度时变性的岩体裂隙注浆扩散模型[J]. 岩石力学与工程学报, 2005, 24(15): 2709-2714. RUAN Wenjun. Spreading model of grouting in rock mass fissures based on time-dependent behavior of viscosity of cement-based grouts[J]. Chinese Journal of Rock Mechanics and Engineering, 2005, 24(15): 2709-2714. [7] 李术才,刘人太,张庆松,等. 基于黏度时变性的水泥-玻璃浆液扩散机制研究[J]. 岩石力学与工程学报, 2013, 32(12): 2415-2421. LI Shucai, LIU Rentai, ZHANG Qingsong, et al. Research on C-S slurry diffusion mechanism with time-dependent behavior of viscosity[J]. Chinese Journal of Rock Mechanics and Engineering, 2013, 32(12): 2415-2421. [8] GUSTAFSON G, CLAESSON J, FRANSSON Å. Steering Parameters for Rock Grouting[J]. Journal of Applied Mathematics, 2013, 22(5): 1-9. [9] GOTHÄLL R, STILLE H. Fracture dilation during grouting[J]. Tunnelling and Underground Space Technology, 2009, 24(2): 126-135. [10] RAFI J Y, STILLE H. Basic mechanism of elastic jacking and impact of fracture aperture change on grout spread, transmissivity and penetrability[J]. Tunnelling and Underground Space Technology, 2015, 49: 174-187. [11] 李术才, 孙子正, 刘人太, 等. 基于裂隙动水注浆的水泥-水玻璃浆液相界面特征研究[J]. 岩石力学与工程学报, 2013, 32(8): 1640-1646. LI Shucai, SUN Zizheng, LIU Rentai, et al. Research on phase interface characteristics of cement-silicate grout based on crack grouting with dynamic water[J]. Chinese Journal of Rock Mechanics and Engineering, 2013, 32(8): 1640-1646. [12] 刘健,刘人太,张霄,等.水泥浆液裂隙注浆扩散规律模型试验与数值模拟[J]. 岩石力学与工程学报,2012, 31(12): 2445-2452. LIU Jian, LIU Rentai, ZHANG Xiao, et al. Diffusion law model test and numerical simulation of cement fracture grouting[J]. Chinese Journal of Rock Mechanics and Engineering, 2012, 31(12): 2445-2452. [13] 李术才,张霄,张庆松,等. 地下工程涌突水注浆止水浆液扩散机制和封堵方法研究[J]. 岩石力学与工程学报, 2011, 30(12): 2377-2396. LI Shucai, ZHANG Xiao, ZHANG Qingsong, et al. Research on mechanism of grout diffusion of dynamic grouting and plugging method in water inrush of underground engineering[J]. Chinese Journal of Rock Mechanics and Engineering, 2011, 30(12): 2377-2396. [14] KAYABASI A, GOKCEOGLU C. An assessment on permeability and grout take of limestone: a case study at Mut Dam, Karaman, Turkey[J]. Water, 2019, 11(12): 2649. [15] 张民庆, 孙国庆, 彭峰. 铁路隧道地表垂直注浆技术研究与应用[J]. 铁道工程学报, 2017, 34(3): 41-45. ZHANG Minqing, SUN Guoqing, PENG Feng. Study and application of the surface vertical grouting technology on the railway tunnel[J]. Journal of Railway Engineering Society, 2017, 34(3): 41-45. [16] 张健,李术才,张乾青,等. 覆盖型岩溶地基注浆处理与效果检测分析[J]. 建筑结构学报, 2017, 38(9): 167-173. ZHANG Jian, LI Shucai, ZHANG Qianqing, et al. Grouting treatment of foundation in covered karst region and effect detection analysis[J]. Journal of Building Structures, 2017, 38(9): 167-173. [17] 国家建筑材料工业局.硅酸盐水泥、普通硅酸盐水泥: GB175—1999 [S]. 北京:中国计划出版社, 1999. [18] 张连震. 地铁穿越砂层注浆扩散与加固机理及工程应用[D]. 济南:山东大学, 2017. ZHANG Lianzhen. Study on penetration and reinforce-ment mechanism of grouting in sand layer disclosed by subway tunnel and its application[D]. Jinan: Shandong University, 2017. [19] 李术才,韩伟伟,张庆松,等. 地下工程动水注浆速凝浆液黏度时变特性研究[J]. 岩石力学与工程学报, 2013, 32(1): 1-7. LI Shucai, HAN Weiwei, ZHANG Qingsong, et al. Research on time-dependent behavior of viscosity of fast curing grouts in underground construction grouting[J]. Chinese Journal of Rock Mechanics and Engineering, 2013, 32(1): 1-7. [20] 李术才,刘人太,张庆松,等. 基于黏度时变性的水泥-玻璃浆液扩散机制研究[J]. 岩石力学与工程学报, 2013, 32(12): 2415-2421. LI Shucai, LIU Rentai, ZHANG Qingsong, et al. Research on C-S slurry diffusion mechanism with Time-dependent behavior of viscosity[J]. Chinese Journal of Rock Mechanics and Engineering, 2013, 32(12): 2415-2421. [21] 迟建平. 超细水泥注浆在青岛地铁隧道初期支护渗漏水治理中的试验研究[J]. 隧道建设,2015, 35(8): 759-765. CHI Jianping. Experimental study on control of water leakage of primary support of tunnel of Qingdao metro by micro-cement grouting[J]. Tunnel Construction, 2015, 35(8): 759-765. [22] 中华人民共和国住房和城乡建设部. 建筑与市政工程地下水控制技术规范 JGJ 111—2016[S]. 北京: 中国建筑工业出版社, 2017. [23] 李相辉,张庆松,张霄,等.水泥浆析水性能试验研究[J]. 建筑材料学报, 2018, 21(1): 8-14. LI Xianghui, ZHANG Qingsong, ZHANG Xiao, et al. Research on water-bleeding property of cement slurry[J]. Journal of Building Materials, 2018, 21(1): 8-14.