Rapid construction of three-lane highway rock-soil mixed tunnel with single-side heading method
QIAO Xiong1, NI Weilin1, LUO Weibin2*, LIU Wengao1
1. School of Civil Engineering, Lanzhou University of Technology, Lanzhou 730050, Gansu, China; 2. Gansu Tunnel Engineering Technology Research Center, Gansu Road and Bridge Construction Group Co., Ltd., Lanzhou 730050, Gansu, China
Abstract: In order to study the rapid construction technology of the single-side heading method, the proposed three-lane highway rock-soil mixed tunnel that in the Dashuidong Village Highway Section in Laizibao Township, Yuzhong County, Lanzhou City, Gansu Province were based on to study the method. The overlying stratum of the tunnel site is the Quaternary Upper Pleistocene aeolian loess(Qeol3), and the underlying bedrock is the precambrian Gaolan Group hornblende schist(AnC-gla). The MIDAS/GTS finite element software was used to compare the single in the sidewall pilot method, the partition wall was optimized for half-width construction. Through two-dimensional numerical simulation, the structural force characteristics and displacement change law of the optimized single sidewall pilot method and the optimized single sidewall pilot method were compared. The results showed that: the force of the supporting structure at each stage under the two construction methods was similar. The final settlement and convergence were also the same; after the optimization of the construction method, the displacement law during the construction process was similar and both it could meet the requirements of construction stability, and the optimized single-wall pilot method had more advantages in terms of construction schedule and economic benefits.
乔雄, 倪伟淋, 骆维斌, 刘文高. 三车道公路岩土混合隧道单侧壁导坑法快速施工[J]. 隧道与地下工程灾害防治, 2021, 3(2): 33-42.
QIAO Xiong, NI Weilin, LUO Weibin, LIU Wengao. Rapid construction of three-lane highway rock-soil mixed tunnel with single-side heading method. Hazard Control in Tunnelling and Underground Engineering, 2021, 3(2): 33-42.
[1] 《中国公路学报》编辑部.中国隧道工程学术研究综述·2015[J].中国公路学报, 2015,28(5): 1-65. Editorial Department of China Journal of Highway and Transport. Review on China's tunnel engineering research: 2015[J].China Journal of Highway and Transport, 2015, 28(5): 1-65. [2] 陈建勋,罗彦斌,万利,等.超大跨度公路隧道研究现状与面临的挑战[J].筑路机械与施工机械化, 2018, 35(6): 36-44. CHEN Jianxun, LUO Yanbin, WAN Li, et al. Research status and challenges of highway tunnel with super long span[J].Road Machinery & Construction Mechanization, 2018, 35(6): 36-44. [3] 王涵,高永涛,李建旺.隧道穿越断层破碎带施工方案及力学效应研究[J].公路, 2021,66(2): 316-323. WANG Han, GAO Yongtao, LI Jianwang. Research on construction plan and mechanical effect of highway tunnel crossing fault fracture zone[J]. Highway, 2021, 66(2): 316-323. [4] 叶林. 浅埋大跨度隧道施工对地表沉降影响的研究[D].贵阳:贵州大学,2017. YE Lin. Study on the influence of shallow buried large span tunnel construction on ground settlement[D]. Guiyang: Guizhou University, 2017. [5] 杨招,黄强兵,肖双全,等.地裂缝场地地铁隧道施工CRD工法优化研究[J].工程地质学报,2021,29(2):516-525. YANG Zhao, HUANG Qiangbing, XIAO Shuangquan, et al. Study on optimization of CRD construction method for metro tunnel through ground fissure site[J]. Journal of Engineering Geology, 2021, 29(2): 516-525. [6] 牟智恒,严涛,田明杰,等.邻路基变坡条件下浅埋偏压隧道施工工法及合理开挖工序研究[J].土木工程学报,2017,50(增刊2):203-208. MOU Zhiheng, YAN Tao, TIAN Mingjie, et al. Research on the construction method and reasonable excavation sequence of shallow tunnel with unsymmetrical loadings adjacent to changing roadbed slope[J]. China Civil Engineering Journal, 2017, 50(Suppl.2): 203-208. [7] 戴润军,李东顺,张成勇.宝兰客运专线软岩隧道三台阶七步开挖法及机械配套快速施工技术[J].隧道建设,2015,35(增刊2):76-85. DAI Runjun, LI Dongshun, ZHANG Chengyong. Construction technologies for three-bench-seven-step excavation method and equipment matching of soft rock tunnel on Baoji-Lanzhou Passenger-Dedicated Railway Line[J].Tunnel Construction, 2015, 35(Suppl.2): 76-85. [8] 夏海,徐光阳,傅金阳,等.黄土隧道三台阶施工预制临时仰拱技术及应用研究[J/OL].隧道建设(中英文).[2021-06-30].http://kns.cnki.net/kcms/detail/44.1745.U.20210416.0933.002.html. XIA Hai, XU Guangyang, FU Jinyang,et al. Study on the technology and application of precast temporary inverted arch for three-step construction of loess tunnel [J/OL].Tunnel Construction.[2021-06-30]. http: // kns.cnki.net /kcms/detail/ 44.1745.U. 20210416. 0933. 002.html. [9] 迟作强,冯建,李月朋.超大跨度隧道半步CD法拆撑安全性分析[J].公路,2017,62(9):4-7. CHI Zuoqiang, FENG Jian, LI Yuepeng. Safety analysis of dismantling of super-span tunnels by half-step CD method[J]. Highway, 2017, 62(9): 4-7. [10] 侯福金,孙克国,赵然,等.超大断面小净距隧道工法适用性研究[J].土木工程学报,2017,50(增刊1):111-116. HOU Fujin, SUN Keguo, ZHAO Ran, et al. Applicability study on construction method of super-largesection neighborhood tunnel[J]. China Civil Engineering Journal, 2017, 50(Suppl.1): 111-116. [11] 罗彦斌,石州,陈建勋,等.超大跨度隧道上台阶CD法中隔壁力学计算模型及施工力学行为研究[J].中国公路学报, 2020,33(12):235-248. LUO Yanbin, SHI Zhou, CHEN Jianxun, et al. Mechanical calculation model and research on construction mechanical behavior of middle diaphragm in upper bench CD method for super-large span tunnel[J]. China Journal of Highway and Transport, 2020, 33(12): 235-248. [12] 中华人民共和国交通运输部.公路隧道设计规范 第一册 土建工程:JTG 3370.1—2018[S].北京:人民交通出版社, 2019. [13] 刘新军,田俊峰,叶万军,等. 盾构下穿施工对软流塑地层及既有隧道变形影响分析[J].防灾减灾学报, 2020,36(4): 18-25. LIU Xinjun, TIAN Junfeng, YE Wanjun, et al. Analysis of the influence of shield tunneling on the deformation of the soft flow plastic stratum and existing tunnel[J]. Journal of Disaster Prevention and Reduction, 2020, 36(4): 18-25. [14] 许成杰. 深基坑开挖对周边环境的影响研究[D].长春:吉林建筑大学,2019. XU Chengjie. Research on the influence of deep excavation on surrounding environment[D]. Changchun:Jilin Jianzhu University, 2019. [15] 何俊,王安民,钱伊默,等. 偏压连拱隧道施工先、后行洞受力变形分析[J]. 公路, 2020,65(12): 137-140. HE Jun, WANG Anmin, QIAN Yimo, et al. Analysis on the force deformation of the firstly and secondly constructed tubes of biased double arch tunnel[J]. Highway, 2020, 65(12): 137-140. [16] 仇明,张胜,夏鑫,等. 浅埋偏压隧道进洞方案优化与边坡稳定性分析[J]. 湖南城市学院学报(自然科学版), 2019,28(4): 1-5. QIU Ming, ZHANG Sheng, XIA Xin, et al. Scheme optimization of tunnel portal and slope stability analysis under shallow-buried and unsymmetrical loading[J]. Journal of Hu'nan City University(Natural Science), 2019, 28(4): 1-5. [17] 王浩.红山隧道仰拱变形机理及控制措施研究[D].阜新:辽宁工程技术大学,2020. WANG Hao. Study on the invert arch deformation mechanism and remediation measures of Hongshan Tunnel[D]. Fuxin: Liaoning Technical University, 2020. [18] 乔雄. 黄土隧道洞口段支护结构力学特性研究[D].西安:长安大学, 2009. QIAO Xiong. Study on supporting structure mechanical properties of tunnel in loess portal sector[D]. Xi'an: Chang'an University, 2009. [19] 蔡科.浅埋大跨度隧道的施工力学特性研究[D].贵阳:贵州大学, 2017. CAI Ke. Study on construction mechanical characteristics of shallow buried long span tunnel[D].Guiyang: Guizhou University, 2017. [20] 杨东升. 地表水入渗对浅埋大断面黄土隧道稳定性影响分析[D].西安:西安工业大学,2018. YANG Dongsheng. Analysis of the influence of surface water infiltration on the stability of shallow buried large section loess tunnel[D]. Xi'an:Xi'an Technological University, 2018.
2021, Vol. 3 
